1 INTRODUCTION Congratulations on your selection of a Honda lawn mower! We are certain you will be pleased with your purchase of one of the finest lawn mowers on the market. We want to help you get the best results from your new mower and to operate it safely. This manual contains the information on how to do that; please read it carefully.
We suggest you read the DISTRIBUTOR’S LIMITED WARRANTY EMISSION CONTROL SYSTEM WARRANTY ge and your responsibilities of ownership. When your mower needs scheduled maintenance, keep in mind that an authorized Honda servicing dealer is specially trained in servicing Honda mowers and is supported by the parts and service divisions of American Honda. Your Honda dealer is dedicated to your satisfaction and will be pleased to answer your questions and concerns. Keep this owner’s manual handy, so you can refer to it at any time. This owner’s manual is considered a permanent part of the lawn mower and should remain with the lawn mower if resold. The information and specifications included in this publication were in effect at the time of approval for printing. Honda Power Equipment Mfg.
Reserves the right, however, to discontinue or change specifications or design at any time without notice and without incurring any obligation whatever. No part of this publication may be reproduced without written permission. SAFETY MESSAGES Your safety and the safety of others are very important. We have provided important safety messages in this manual and on the mower. This information alerts you to potential hazards that could hurt you or others. Please read these messages carefully.
Of course, it is not practical or possible to warn you about all the hazards associated with operating or maintaining a lawn mower. You must use your own good judgment. You will find important safety information in a variety of forms:. Safety Labels – on the lawn mower.
Instructions – how to use this mower correctly and safely. Safety Messages – preceded by a safety alert A symbol and one of three signal words: DANGER, WARNING, or CAUTION. These signal words mean: Each message tells you what the hazard is, what can happen, and what you can do to avoid or reduce injury. Damage Prevention Messages – You will also see other important messages that are preceded by the word NOTICE. This word means: CONTENTS. B DANGER You WILL be KILLED or SERIOUSLY HURT if you don't follow instructions.
B WARNING You CAN be KILLED or SERIOUSLY HURT if you don't follow instructions. B CAUTION You CAN be HURT if you don't follow instructions. NOTICE Your engine or other property can be damaged if you don’t follow instructions. 1 SAFETY MESSAGES. 1 IMPORTANT MESSAGE TO PARENTS. 2 SAFETY LABEL LOCATIONS. 2 IS YOUR LAWN MOWER READY TO GO?.
4 CHECK YOUR MOWING AREA. 4 GET THE MOWER READY. 5 SAFE OPERATING PRECAUTIONS. 6 STARTING THE ENGINE. 6 OPERATING THE CONTROLS FOR MOWING.
7 STOPPING THE ENGINE. 8 STOPPING THE ENGINE. 8 MAINTENANCE SAFETY. 9 MAINTENANCE SCHEDULE.
9 BLADE(S).
FREE Standard Shipping on orders of $90 or more Purchase requirement calculated before taxes and shipping charges and after other discounts have been applied and must be made in a single transaction. Cannot be applied to previous purchases and cannot be redeemed for cash. Valid for standard ground shipping within the continental United States and not valid for shipments to Alaska, Hawaii, Puerto Rico, Guam and the US Virgin Islands. Offer valid for online purchases only.
In an event of a return, coupon savings may be deducted from your refund. Discount will be automatically applied during check-out. Sears Holdings reserves the right to terminate or modify this offer at any time for failure to comply with its terms and/or due to any operational malfunction of the software, hardware or equipment required to process this offer.
© 2013 Sears Brands, LLC. May not be used with any other coupon, associate discount, or during Family & Friends or Member events. 365 Day Return Policy You may return an unused and uninstalled part in its original packaging. To return a part, enter your order number/zipcode above and continue through the return process to obtain a Return Authorization number. We must receive the returned part(s) with the Return Authorization number within 365 days of your original order date.
Exclusions apply to products with limited shelf life, which includes but are not limited to batteries, smoke detectors, or chemical based products; these products must be returned within 90 days of the original order date. Items received damaged must be reported within 10 days of receipt. Credit will be issued for the part(s) plus tax, minus any shipping charges.
. EMISSION SYSTEM WARRANTY.TROUBLESHOOTING SERVICING YOUR MOWER PRODUCT REGISTRATION.Engine Will Not Start.Maintenance Safety.QUESTIONS? Contact your Honda dealer. There is a dealer locator at powerequipment.honda.com 00X31VL0 N030 © 2014 American Honda Motor Co., Inc. All Rights Reserved. Honda lawn mowers and are supported by the Important Message to Parents parts and service divisions of American Honda.
Hrr216vka Service Manual
The safety of your children is very important to Honda. Lawn mowers Please read the DISTRIBUTOR’S LIMITED WARRANTY on page 21 are tools, not toys. With help from an assistant, carefully remove the mower and loose parts from the carton and compare the loose parts against the REAR following list. Contact the authorized Honda dealer from whom you DISCHARGE (P. 5) purchased the mower if any of the loose parts shown are not included GUARD with your mower.
Look for things like stones, sticks, nails, and wire, and remove them from the lawn area. Please take a few minutes and register your purchase with Honda. People and animals near the lawn area can move into your lawn You can register by completing and mailing the registration card on mower’s path or into a position where they could be struck by thrown. Remove the grass bag and raise the discharge guard to check the to snap into the groove. Rear shield for cracks or tears. If the rear shield is excessively worn, have it replaced by your authorized Honda servicing dealer.
Mulching DISCHARGE GUARD Set the clip director lever in the MULCH position. Installation 2. Insert and remove the DISCHARGE GUARD dipstick without 1. Raise the screwing it into the discharge guard GRASS BAG filler neck. Check the oil and hook the grass HANDLE level shown on the bag onto the dipstick. Mower deck as 3.
Remove the fuel tank cap. Add fuel to the bottom of the red fuel level gauge in the neck of the fuel tank. Do not overfill. Wipe up spilled fuel before starting The blades are sharp and spin at high speed. A spinning blade the engine.
If stuck, do not kick or shove the mower with your foot. Use the additional pressure will not further increase ground speed. Apply only handlebar to control the mower. Enough pressure to achieve the desired speed. Release the Smart Drive control to disengage the drive when mowing Avoid Obstacles around trees and other obstacles. Remember that an authorized Honda servicing dealer knows your mower best and is fully equipped to maintain and repair it. To ensure the best quality and reliability, use only new, Honda Genuine parts or their equivalents for repair and replacement.
Honda Hrr216vka Shop Manual
(2) Change engine oil every 25 hours when used under heavy load or in high outside air temperatures. (3) These items should be serviced by an authorized Honda servicing dealer unless you have the proper tools and are mechanically proficient. Refer to the Honda shop manual for service procedures. See “Honda Publications” on page 20 for ordering information.
EXCESSIVELY WORN TRAILING EDGE NORMAL WORN BENT CRACKED LOWER BLADE If a blade is bent, take the lawn mower to an authorized Honda BLADE BOLT 2 servicing dealer for inspection. AND WASHER 2 SPECIAL WASHER Blade Mounting Bolt Inspection DIRECTION 4. Place a suitable container We recommend the use of a Honda Genuine air filter to ensure it next to the mower to catch seals and performs as designed. Using a non-Honda air filter can the used oil, and then tilt result in dirt bypassing the filter, causing damage to the engine or fuel the mower on its right side.
Release the blade control lever; the engine should stop quickly. WASHER bending the side If it does not, take your mower to an authorized Honda servicing electrode. Dealer for repair.
Hrr216vka Shop Manual
Install the spark plug carefully, by hand, to BLADE CONTROL avoid cross-threading. Cable Adjustment STORAGE ADJUSTER JAM NUT With the engine off, loosen the MARK adjuster jam nut.
Without pushing the Smart Drive Proper storage preparation is essential for keeping your lawn mower control, pull the lawn mower trouble free and looking good. To help keep rust and corrosion from TIGHTEN backwards to check wheel impairing your lawn mower’s function and appearance, and to make.
Take the mower to an authorized Place the mower with its wheels on a level surface. Tilting can cause carburetor malfunction, Honda servicing dealer for repair. Fuel or oil leakage.
Ignition malfunction, valves With the engine and exhaust system cool, cover the mower to keep stuck, etc. The following instructions and procedures must be followed in order to keep the emissions from your Honda engine within the emissions standards. Tampering and Altering ENGINE. Misfiring, backfiring under load, or afterburning. Black exhaust smoke or high fuel consumption Replacement Parts The emissions control systems on your new Honda engine were designed, built, and certified to conform with EPA, California, and Canadian emissions regulations. We recommend the use of Honda Genuine parts whenever you have maintenance done.
Mower Features (cold) Actual amount will vary due to residual oil in the engine. Always HRR216K9VKA Honda rotary mower, 21-inch mower deck, use the dipstick to confirm the actual level (page 3-in-1 Clip Director, Smart Drive variable speed transmission, flywheel brake, fixed. Do not try to increase the engine speed above the maximum throttle, Auto Choke System™. AVOIDING FUEL-RELATED PROBLEMS When properly maintained, your Honda lawn mower should provide years of trouble-free operation. This includes the fuel system. However, gasoline can quickly deteriorate (in as little as 30 days) causing starting or running problems and, in some cases, damage to the fuel system.
The information and specifications included in this publication were in -C6 1-1/4 gallon ® NO-SPILL effect at the time of approval for printing. American Honda Motor Co., gas cans Inc. Reserves the right, however, to discontinue or change -C6 2-1/2 gallon.
OUR MANUAL IS REGULAR BOUND, NOT LOOSE LEAF OR RING BOUND FORD TRACTOR MODELS 1320, 1520 & 1720 FACTORY REPAIR SHOP. Ford 1520 tractor reviews.
What American Honda Will Repair or Replace Under Warranty: purchased for installation on original Honda equipment or engines to be eligible American Honda will repair or replace, at its option, any part that is proven to be for warranty coverage. Installing parts and accessories on non-Honda products defective in material or workmanship under normal use during the applicable or engines voids this warranty. Honda Power Equipment dealer Equipment engine.
In California, new spark-ignited small off-road equipment who is authorized by Honda to sell and service that Honda product during their engines must be designed, built, and equipped to meet the state's stringent normal business hours. From time to time, American Honda conducts sales promotions that require you to register your lawn mower within 30 days of purchase. If you purchased your Honda lawn mower during one of these promotions, you must register your mower within 30 days. Go to PowerEquipment.Honda.com to register your unit. Fundamentals of investing gitman solutions manual. Click on Product Registration. Complete the required information and click Submit. It’s that simple!
NO POSTAGE NECESSARY Product Registration IF MAILED IN THE UNITED STATES BUSINESS REPLY MAIL FIRST-CLASS MAIL PERMIT NO.